Product ID:5013 DS-67 AEROSOL
MSDS Date:07/25/1991
FSC:6850
NIIN:00F038568
MSDS Number: BWVGP

NATIONAL CHEMSEARCH DIV OF NCH CORP

2727 CHEMSEARCH BLVD
IRVING, TX 75015-5000
US

Emergency Phone: 800-527-9919/214-438-1381

Info Phone: 800-527-9919/214-438-1381

Preparer: D ABELL

Cage: 0TTE8

NATIONAL CHEMSEARCH

IRVING, TX 75015 US

Telephone: 214-438-4144

Cage: 0TTE8

METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),

CAS: 71-55-6

RTECS: KJ2975000

OSHA PEL 350 PPM

ACGIH TLV: 350 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA

CAS: 8030-30-6

RTECS: DE3030000

OSHA PEL 100 PPM

ACGIH TLV: 300 PPM

TOLUENE (IARC CARCINOGEN- GROUP 3) *95-1*

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

OSHA PEL 5000 PPM

ACGIH TLV: 5000 PPM

LD50 LC50 Mixture:ORAL LD50 (RAT): 5000 MG/KG TOLUENE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION & TRANSIENT
CORNEAL INJURY. SKIN: IRRITATION & DERMATITIS. INHALATION: NASAL &
RESPIRATORY IRRITATION, ASPHYXIATION, CNS DEPRESSION & KIDNEY
DAMAGE. INGESTION: ASPIRATION OF MA TERIAL INTO LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DIZZINESS, WEAKNESS, NAUSEA, UNCONSCIOUSNESS, CRAMPS,
VOMITING, DIARRHEA.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 10 MINS. SKIN: THOROUGHLY
WASH W/SOAP & WATER. APPLY EMOLLIENT RICH CREAM. INGESTION: DON'T
INDUCE VOMITING. ASPIRATION HAZARD. KEEP WARM & QUIET. OBTAIN
MEDICAL ATTENTION IN ALL CASES. NOTES TO PHYSICIAN: GASTRIC LAVAGE
SHOULD BE CONSIDERED DEPENDING ON AMOUNT
INGESTED/RETAINED/TOXICITY. (SUPP)

Flash Point Method:TCC
Flash Point:82F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:SPRAY WATER ON AEROSOL CONTAINERS TO COOL THEM
& AVOID RUPTURING AEROSOL CONTAINER. WEAR SELF CONTAINED BREATHING
APPARATUS & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FLAME EXTENSIONS: >18 INCHES.

Spill Release Procedures:AEROSOL CONTAINER SO SPILL UNLIKELY. IN CASE
OF LEAKAGE, PICKUP W/AN ABSORBENT/PAPER/VERMICULITE TO CONTAIN.
DON'T FLUSH TO SEWER. PLACE INTO LABELED CONTAINERS & SEAL. WET
VACUUM AREA AFTER ALL TRACE S HAVE BEEN CLEANED UP.

Handling and Storage Precautions:STORE BETWEEN 32-120F & INDOORS. KEEP
AWAY FROM IGNITION SOURCES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING. NEVER POINT SPRAY HEAD TOWARD FACE.

Respiratory Protection:TYPICAL USE OF PRODUCT DOESN'T REQUIRE USE OF A
RESPIRATOR. WEAR A NIOSH APPROVED MASK IF MISTING.
Ventilation:LOCAL EXHAUST SUFFICIENT TO MAINTAIN WORKPLACE
CONCENTRATION BELOW PERMISSABLE EXPOSURE LIMITS.
Protective Gloves:NEOPRENE/RUBBER
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: EXCESSIVE OVEREXPOSURE MAY CAUSE CNS ,
LIVER/KIDNEY EFFECTS. FIRST AID CONT'D: KEEP PATIENT'S HEAD BELOW
HIPS TO PREVENT PULMONARY ASPIRATION. IF COMATOSE, A CUFFED
ENDOTRACHAEL TUBE WILL PREVENT ASPIRATION.

Boiling Pt:B.P. Text:160F
Vapor Pres:11
Vapor Density:2
Spec Gravity:1.15
Evaporation Rate & Reference:(BU AC = 1): 0.75
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSPARENT, COLORLESS, NON-VISCOUS W/MINT/SOLVENT
ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:CO & TRACE AMOUNT OF PHOSGENE.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.